1994 Buick Roadmaster Limited Review

Summary: DEFECTIVE LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS WERE NOT PROPERLY TORQUED AND CAN LOOSEN.

Consequence: IF THE LOWER CONTROL ARM BALL JOINT LOOSENS, FATIGUES AND SEPARATES FROM THE FRONT SUSPENSION KNUCKLE, IT COULD CAUSE LOSS OF VEHICLE CONTROL.

Remedy: DEALERS WILL INSPECT BOTH FRONT LOWER CONTROL ARM BALL JOINT ATTACHMENT NUTS FOR PROPER TORQUE. IF THE BALL JOINT HAS LOOSENED FROM THE KNUCKLE, BOTH THE BALL JOINT AND THE KNUCKLE WILL BE REPLACED.

Notes: SYSTEM: SUSPENSION; INDEPENDENT FRONT CONTROL ARM; LOWER; BALL JOINT. VEHICLE DESCRIPTION: PASSENGER VEHICLES EXPORTED TO GUAM AND PUERTO RICO. NOTE: OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME, SHOULD CONTACT CHEVROLET AT 1-800-222-1022, BUICK AT 1-800-521-7300, OR CADILLAC AT 1-800-458-8006. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Summary: THESE VEHICLES FAIL TO CONFORM TO FMVSS NO. 124, "ACCELERATOR CONTROL SYSTEMS." AT LOW TEMPERATURES, EXCESSIVE FRICTION CAN OCCUR IN THE ACCELERATOR PEDAL ASSEMBLY.

Consequence: CONSEQUENCE OF NON-COMPLIANCE: IN THE EVENT OF A FAILURE OF THE TROTTLE RETURN SPRING, IF THERE IS EXCESSIVE FRICTION IN THE PEDAL ASSEMBLY, THE ENGINE SPEED MAY NOT RETURN TO IDLE INCREASING THE POTENTIAL FOR A VEHICLE CRASH.

Remedy: DEALERS WILL REPLACE THE ACCELERATOR PEDAL ASSEMBLY.

Notes: SYSTEM: FUEL; THROTTLE LINKAGES AND CONTROL; RETURN SPRING; FMVSS NO. 124.VEHICLE DESCRIPTION: PASSENGER VEHICLES.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME, PLEASE CONTACT CHEVROLET AT 1-800-222-1020, BUICK AT 1-800-521-7300, OR CADILLAC AT 1-800-458-8006. ALSO CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Summary: THE FUEL TANK ATTACHMENT STRAP FASTENERS WERE NOT PROPERLY TIGHTENED. THE FASTENERS CAN COMPLETELY DETACH, EVENTUALLY ALLOWING THE FUEL TANK TO SAG AND THE BOTTOM OF THE TANK TO STRIKE THE ROADWAY.

Consequence: THIS CAN RESULT IN A FUEL TANK LEAK AND FIRE IF THE LEAKING FUEL IS EXPOSED TO A SOURCE OF IGNITION.

Remedy: DEALERS WILL RETIGHTEN THE FUEL TANK STRAP FASTENERS.

Notes: SYSTEM: FUEL; FUEL TANK ASSEMBLY; ATTACHMENTS.VEHICLE DESCRIPTION: PASSENGER VEHICLES.NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED FREE OF CHARGE WITHIN A REASONABLE TIME OR THE REMEDY DOES NOT CORRECT THE DEFECT, PLEASE CONTACT CHEVROLET AT 1-800-222-1020; CADILLAC AT 1-800-458-8006; OR BUICK AT 1-800-521-7300. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Summary: PAINT ON THE WHEEL MOUNTING SURFACES CAN ACT AS A SHIM BETWEEN THE WHEEL AND THE ROTOR/DRUM. AS THE VEHICLE IS DRIVEN, THE WHEEL IMBEDS INTO THE PAINT, LOOSENING THE LUG NUT AND CAUSING A LOSS OF CLAMP LOAD.

Consequence: ONCE CLAMP LOAD IS LOST, ALL TIRE LOADS ARE TAKEN BY THE WHEEL STUDS RESULTING IN A FRACTURE OF THE WHEEL STUDS. THIS COULD CAUSE THE WHEEL TO SEPARATE FROM THE VEHICLE AND COULD RESULT IN A VEHICLES CRASH WITHOUT PRIOR WARNING.

Remedy: DEALERS WILL CLEAN THE WHEEL MOUNTING SURFACES FOR ALL FOUR WHEELS. ALSO, THE WHEEL STUDS WILL BE INSPECTED FOR DAMAGE AND WILL BE REPLACED AS NECESSARY.

Notes: SYSTEM: WHEELS; LUG NUTS; BOLTS.VEHICLE DESCRIPTION: PASSENGER CARS. NOTE: IF YOUR VEHICLE IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME AND FREE OF CHARGE OR THE REMEDY DOES NOT CORRECT THE DEFECT OR NONCOMPLIANCE, PLEASE CONTACT CHEVROLET AT 1-800-222-1020, BUICK AT 1-800-521-7300, OR CADILLAC AT 1-800-458-8006. ALSO, PLEASE CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.

Summary: THE ENGINE OIL COOLER INLET HOSE MAY HAVE BEEN INSTALLED TOO CLOSE TO THE STEERING GEAR CAUSING CHAFING. THE CHAFING CAN EVENTUALLY WEAR THROUGH THE HOSE'S PROTECTIVE SLEEVE RESULTING IN ENGINE OIL LEAKING ONTO THE ENGINE.

Consequence: IF THIS OCCURS, THE OIL LEAK ONTO THE ENGINE CAN RESULT IN AN ENGINE COMPARTMENT FIRE.

Notes: SYSTEM: ENGINE COOLING SYSTEM: HOSES.VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH ENGINE OIL COOLERS AND 5.7L OR 4.3L ENGINES.NOTE: IF YOUR EQUIPMENT IS PRESENTED TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND THE REMEDY IS NOT PROVIDED WITHIN A REASONABLE TIME OR THE REMEDY DOES NOT CORRECT THE DEFECT OR NONCOMPLIANCE, PLEASE CONTACT CHEVROLET SERVICE CENTER AT 1-800-222-1020, BUICK SERVICE CENTER AT 1-800-521-7300, OR CADILLAC SERVICE CENTER AT 1-800-458-8006. ALSO, CONTACT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION'S AUTO SAFETY HOTLINE AT 1-800-424-9393.